燃油蒸汽锅炉出现故障时应该注意什么?

燃油蒸汽锅炉采用水管贯流式炉胆结构,并配备安全阀,温度过热,水位过低,压力过高等四重保护,绝对安全可靠。燃油蒸汽锅炉操作简单,只需按下按钮,既进入自动运行状态,无需专人值守。但是它也会有出现故障的时候,那么在平时的使用中,应该注意些什么呢?

1、使用蒸汽锅炉应特别注意锅炉房的通风条件,万一发生泄漏,如果通风不好的话,极易引起液态气在地面上凝结和扩散,造成恶性爆炸事故。
Special attention should be using the steam boiler boiler room ventilation, if leaks occur if ventilation is not good, can easily cause condensation of liquid gas in the ground and spread vicious explosion.
2、锅炉人员应时刻注意气体阀门的开关情况。气体管路不可漏气,若有异常情况,如锅炉房内有异常气味,不可开启燃烧器,应及时检查通风情况,排除气味,检查阀门,正常后才可投入运行。
Boiler should always pay attention to the situation of gas valve switch. Gas pipeline can not leak, if unusual circumstances, such as the boiler room abnormal odor, not open burners, ventilation should be checked to exclude odor, check valves, to get ready for normal operation after.
3、气体压力不可过高和过低,应在设定的范围内运行,具体参数由蒸汽锅炉生产厂家提供。当锅炉运行一段时间,发现气体压力低于设定值时,应及时与煤气公司联系,供气压力是否有变化。燃烧器运行一段时间,应及时检查管路中过滤器是否清洁,如气压下降很多,有可能是气体杂质过多,过滤器被堵塞,应拆下清洗,必要时更换滤芯。
Gas pressure is not too high and too low, should operate within a set range, specific parameters provided by the steam boiler manufacturer. When the boiler is running for some time, found that the gas pressure is lower than the set value, it is timely contact with the gas company, if there is change in air pressure. Burner running for some time, should be checked in the pipeline filter is clean, like a lot of pressure decline, there may be too much gas impurities, the filter is clogged, remove the cleaning, replace the filter when necessary.
4、在停运一段时间或检查管路后,在重新投入运行时,应打开放空阀,放气一段时间,放气时间应根据管路长短及气体种类来确定。若锅炉停用时间较长,则应切断煤气供应总阀,关闭放空阀。
After the outage or check the pipeline for some time, when put into operation again, open the vent valve, bleed for some time, deflated time should be determined according to the length and type of gas pipeline. If the boiler is disabled longer time, you should cut off the gas supply valve, close the vent valve.

电蒸汽锅炉http://www.jnshengxin.cn/


上一条:电热水锅炉厂家谈锅炉选型有哪些技巧
下一条:电蒸汽锅炉节能技术又立新规范

热门产品推荐